公司立足常州地区经营产品涵盖铝艺围墙护栏、锌钢企业护栏、各式铝艺阳台护栏、铝艺大门、铝艺楼梯扶手、门窗系统,车库门、新型阳光房等多领域。

示例图片三
网站首页 > 新闻资讯 > 铝艺大门

环氧地坪漆施工时地面特殊情况处理方案

2019-06-20 14:46:42 常州市星火铝艺制品有限公司 阅读

根据环氧地坪漆厂家工程施工的相关经验,在环氧地坪施工过程中有可能会出现以下几种地面问题,环氧地坪漆厂家建议采用以下解决方案:一、混凝土表面有裂纹、脱皮、麻面、起砂等现象或有油污时的处理方案:如基础地面小范围出现轻微裂缝(不影响环氧地坪施工)时,对问题地面进行处理,有裂纹处使用光磊环氧涂料进行填充。

According to the construction experience of Guanglei Epoxy Floor Paint Factory, the following ground problems may occur during the construction of epoxy floor paint. The epoxy floor paint manufacturer suggests the following solutions: 1. Treatment schemes for concrete surface with cracks, peeling, flax, sand or oil contamination, such as slight cracks in a small area of foundation ground (without affecting epoxy). During floor construction, the problem ground is treated, and the cracks are filled with epoxy coating.

如地面出现脱皮、麻面及起砂部位打扫干净后使用光磊环氧封闭底涂材料进行渗透加固处理,以增强基础地面的附着力,脱皮及裂缝处使用环氧砂浆材料批补,以保证整体地面的平整度,我单位将根据基层加固使用材料情况收取相应加固材料成本费。

If the surface is desquamated, linen surface and sand-lifting parts are cleaned, the surface of the ground is strengthened by using glazed epoxy sealed primer material to enhance the adhesion of the foundation ground, and epoxy mortar material is used to repair the desquamation and cracks in order to ensure the levelness of the whole ground. Our unit will charge the cost of reinforcing material according to the use of the base reinforcement material.

特殊混凝土地面处理

Special concrete ground treatment二、基面含水率在6%以上时施工处理方案:

2. When the water content of the base surface is above 6%, the construction treatment scheme shall be as follows:

一般环氧地坪漆对基面含水率的要求是不高于4%,如果混凝土基面含水率高,而且又湿潮可选择做泥找平层解决基础地面含水量高和潮湿的问题;(成本另计)

Generally, epoxy floor paint requires no more than 4% moisture content of the base surface. If the moisture content of the concrete base surface is high and wet, mud leveling layer can be chosen to solve the problem of high moisture content and humidity of the base surface; (Cost added)

在含水率不是很高的情况下可做防潮层处理或者采用防水底漆做封闭材料,做好混凝土基础地面的干燥工作。

When the moisture content is not very high, it can be treated as a moisture-proof layer or waterproof primer as a sealing material to do a good job of drying the concrete foundation ground.

如在铺设混凝土基础层时没有做防潮层和防水层的情况下,可使用防潮类的环氧地坪漆施工,防水涂料封底,针对含水率不断升高的的地面,说明地下水游上渗的趋势,就需要做好彻底的防水封底。

If there is no moistureproof layer and waterproof layer when laying concrete foundation layer, we can use moistureproof paint construction, waterproof paint bottom sealing, in view of the rising water content of the ground, indicating the trend of groundwater upstream seepage, we need to do a thorough waterproof bottom sealing.

环氧地坪施工过程中,在混凝土基础地面潮湿,含水率高的情况,在铺设环氧地坪漆之前一定要按照以上的方法解决好含水率高的问题再进行施工,否则,会出现返潮,起水,脱层的现象。(防潮层根据现场具体情况另计)

During the construction of epoxy floor, when the concrete foundation is wet and the water content is high, we must solve the problem of high water content according to the above methods before laying epoxy floor paint. Otherwise, the phenomenon of moisture regain, water rising and delamination will occur. (Moisture-proof layer shall be added according to the specific conditions of the site)

环氧环氧地坪漆施工现场

Construction site of epoxy floor paint三、空气中湿度在85%以上时施工处理方案:

3. Construction treatment scheme when air humidity is above 85%:

根据我单位环氧地坪施工经验,在湿度超过85%时,光磊地坪漆厂家建议使用水性聚氨酯地坪施工作业。

According to our unit's experience in epoxy floor construction, when the humidity exceeds 85%, Guanglei floor paint manufacturer recommends the use of waterborne polyurethane floor construction. 



标签:   铝艺大门 常州铝艺大门 铝艺大门厂家 环氧地坪 地坪