公司立足常州地区经营产品涵盖铝艺围墙护栏、锌钢企业护栏、各式铝艺阳台护栏、铝艺大门、铝艺楼梯扶手、门窗系统,车库门、新型阳光房等多领域。

示例图片三
网站首页 > 新闻资讯 > 业界资讯

防腐环氧地坪涂装工艺及验收标准

2018-10-29 17:34:52 常州市星火铝艺制品有限公司 阅读

环氧树脂防腐环氧地坪面涂装工艺的关键在于涂装基面的处理,它关系到涂装层能否牢固附于地面,涂装层是否平整光亮,我公司非常注重对基面的处理。洁净区的地面应整体性好、平整、耐磨、耐撞击,不易积聚静电,易除尘清洗。目前使用环氧自流平地面较普遍,环氧自流平地坪是一种新型的较为理想的地面洁净材料。它具有耐腐蚀和洁净的双重作用,优良的耐磨性能及平整光洁性,从而保证了厂房车间地面的洁净度和整体的美观。

Epoxy resin anti-corrosion floor coating process is the key to the treatment of the base surface, it is related to the coating layer can be firmly attached to the ground, whether the coating is smooth and bright, my company attaches great importance to the treatment of the base surface. Clean area of the ground should be good integrity, smooth, wear-resistant, impact-resistant, not easy to accumulate static electricity, easy to dust cleaning. Epoxy self-leveling floor is widely used at present. Epoxy self-leveling floor is a new kind of ideal ground cleaning material. It has the dual role of corrosion resistance and cleanliness, excellent wear resistance and smoothness, thus ensuring the cleanliness of the workshop floor and the overall beauty.

1、为使涂装达到完美效果,专家建议:对于尚未找平的地面由施工公司参与工地的水泥找平层的找平处理。土建方找平时,在水泥初凝时由施工公司专业地面机械对地面进行磨平处理。在此基础上所做的环氧涂装层的表面效果会更平整、光亮,使用寿命也会提高。

1. In order to achieve the perfect effect of painting, experts suggest that the construction company should take part in leveling the cement leveling layer on the ground which has not been leveled. When the cement is initially set, the ground is ground by the professional ground machinery of the construction company. On this basis, the surface effect of the epoxy coating will be smoother and brighter, and the service life will be improved.

2、待水泥层干燥后大约28 天,用打磨机对地面进行整体打磨处理,使其表面平整,水泥毛细孔全部张开。

2. About 28 days after the cement layer is dried, the ground is polished with a grinder to make the surface smooth and the cement capillaries open.

3、对于水泥地面有油污(食用油、机油),先用美地坚丽处理剂喷洒于用水冲湿的地表面,反复擦洗直到无油污为止。

3. For oily cement floors (cooking oil, oil), spray the surface wetted with water with Medicinal Rubber and scrub repeatedly until there is no oil pollution.

4、对于环氧地坪碱性太大(ph>8)的,先用有关处理剂中和,然后用清水冲洗。

4, for the floor too alkaline (ph>8), first use the relevant treatment agent neutralization, and then rinse with water.

5、对于潮湿的地面通过吸水、擦干、太阳灯照、热风机吹烘,使其干燥达到施工要求。

5. The wet ground is dried to meet the construction requirements by absorbing water, drying, sunlight and hot air blower.

6、对于有旧油漆的地面如金刚砂地面、旧油漆地面,先用机械铲除旧油漆,然后对不良水泥、金刚砂地面进行处理同时对地面打毛。地面经过这样处理后,不牢固的旧水泥及金刚砂表面被清除掉,并且形成粗毛面,从而提高新涂层的附着力,提高涂装环氧地坪的使用寿命。

6. For old painted ground such as diamond ground, old painted ground, first with mechanical shovel old paint, and then on the poor cement, diamond ground treatment and grooming. After the ground is treated in this way, the unstable surface of old cement and diamond is removed, and coarse surface is formed, so as to improve the adhesion of the new coating and improve the service life of the coated floor.

苏州环氧树脂防腐地坪

Suzhou epoxy resin anticorrosive floor 环氧地坪的验收标准:

Acceptance criteria for epoxy floor:

1、环境温度为25℃时,施工后2-3天应达到实干,即硬度达到完成固化的80%左右;

1. When the ambient temperature is 25 C, the hardness should reach 80% after 2-3 days.

2、表面不能出现发粘现象;

2, the surface can not appear sticky phenomenon;

3、气泡:平涂型、砂浆型无气泡,自流平允许1个小气泡/10平方米;

3, bubble: flat coated, mortar type no bubbles, self leveling allows 1 small bubbles /10 square meters;

4、流平性好,无镘刀痕,大面积接口处基本平整;

4, good leveling, no trowel marks, large area of the interface is basically smooth.

5、无浮色发花,颜色均匀一致,大面积接口处允许有极不明显的色差;

5, no floating color and flower, uniform color, large area interface allows very insignificant chromatic aberration;

6、无粗杂质,但允许有空气中的浮尘掉落在造成的极小缺陷;

6, there is no coarse impurity, but it allows the floating dust in the air to drop into the minimal defect.

7、地坪表面应平整平滑,光泽度应达到设计要求(高光泽≥90、有光≥70、半光50~70),平涂型为有光、水性为半光~无光;

7. The surface of the floor should be smooth and smooth, and the gloss should meet the design requirements (high gloss (> 90, gloss (> 70, half gloss 50-70). The flat coating type is glossy and the water-borne is half gloss-no gloss.

8、桔皮、砂浆防滑面效果应很明显。无挥发性有机物排放,被广泛用于现代工业地坪的涂饰中。

8, orange peel and mortar anti slip surface effect should be very obvious. No VOC emissions are widely used in modern industrial floor finishing.



标签:   常州铝艺大门 铝艺大门 铝艺护栏 常州铝艺护栏 环氧地坪