公司立足常州地区经营产品涵盖铝艺围墙护栏、锌钢企业护栏、各式铝艺阳台护栏、铝艺大门、铝艺楼梯扶手、门窗系统,车库门、新型阳光房等多领域。

示例图片三
网站首页 > 新闻资讯 > 业界资讯

为什么环氧地坪漆施工需要中涂层?

2018-10-27 19:24:28 常州市星火铝艺制品有限公司 阅读

看完底漆层和面漆层的介绍,那是不是有疑惑,那干嘛还要施工一个“中涂层”,为什么要有专常州铝艺大门的中涂环氧地坪漆材料?1、底漆层,这个是为了封闭混凝土的空隙,防止地下的水汽、空气,腐蚀性物质上浮对环氧地坪造成损害。2、面漆层,这个图层直接面对使用者,它一方面需要能抗人们的行走,机械的摩擦,另一方面还需要能隔绝外界存在的腐蚀性物质从上层侵入环氧地坪漆内部。

After reading the introduction of the primer and top coat, is it doubtful, then why should a "middle coat" be constructed, why should a special medium coated floor paint materials? 1. Primer layer, this is to close the gap of concrete, prevent underground water vapor, air, corrosive substances floating on the epoxy floor damage. 2. Topcoat, this layer is directly facing the user. On the one hand, it needs to be able to resist people's walking, mechanical friction, on the other hand, it also needs to be able to isolate the external presence of corrosive substances from the upper layer into the interior of the epoxy floor paint. 

这个原因有几点:

There are several reasons for this.

1、增强耐磨性能。环氧地坪漆的性质决定。环氧环氧地坪漆是固化成膜类环氧地坪漆,它是通过在混凝土表面形成保护涂膜来完成它的保护使命,有如我们的皮肤。但因为是成膜,那就是可以被磨损。地坪漆工程越薄,则越容易被磨损光。而中涂就是夹在底漆和面漆中间,提高环氧地坪工程耐磨性能,使用年限的关键。

1, enhance wear resistance. The properties of epoxy floor paint are determined. Epoxy floor paint is a film-cured floor paint. It accomplishes its protection mission by forming a protective coating on the surface of concrete, just like our skin. But because they are film-forming, they can be worn away. The thinner the floor paint is, the easier it is to wear out. And the middle coating is sandwiched between primer and topcoat, improve the wear resistance of epoxy floor engineering, the key to use life.

2、增加厚度。一般的地坪漆底漆和面漆施工后,只会产生0.2-0.5mm的涂层,这样不仅耐磨很差,还给人们走在上面的体验很差。这个大家应该都有感受,厚的环氧地坪工程有一定弹性,走在上面很舒适,摔倒了也不会很疼。

2, increase the thickness. After the general floor paint primer and topcoat application, only 0.2-0.5mm coating will be produced, so not only wear resistance is very poor, but also give people a very poor experience walking on it. Everyone should feel that the thick epoxy floor project has some flexibility, walking on it is very comfortable, fall will not be very painful.

3、降低成本。由于中涂层不需要承担防护各种有害物质侵害的任务,那对他的要求实际上是可以降低一点点的。而且中涂层是在环氧地坪涂层的中间,你再五颜六色也没人能看到,于是色粉可以省掉。所以中涂一般会比面漆和底漆来得便宜。

3, reduce costs. Since the coating does not have to take on the task of protecting against various harmful substances, the requirement for it can actually be reduced a little. And the middle coating is in the middle of the epoxy floor coating, and no one can see the colors, so you can save the pink. Therefore, middle coating is usually cheaper than topcoat and primer.



标签:   铝艺大门 铝艺护栏 常州铝艺大门 常州铝艺护栏 环氧地坪